|
Product Name |
Adhesive 2450 Conductive Adhesive (black) |
| Product Code |
CA 2450 |
| Distributor /
Address |
United ESD.com Inc, 4878
Lakeview Cir, Colorado City, CO |
| Manufacturer /
Address |
Resource Technologies, 237 Nance
Road NE; Calhoun, GA |
| CAS Number |
Proprietary Mixture |
| WHMIS Classification |
Not controlled |
| Chemical Name |
Proprietary mixture |
| Molecular Weight |
Not applicable - mixture |
| Chemical Family |
Pressure sensitive acrylic
adhesive with carbon Black |
Note: All
components of this product appear on the inventory of Chemical
Substances published by the U.S. Environmental Protection Agency (EPA)
under the authority of the Toxic Substances Control Act.
Section 2.
Hazardous Ingredients and Exposure Limits
Components CAS Number
Per cent by weight
TLV Value
None - "No toxic chemicals
subject to the reporting requirements of Section 313 of Title III and of
40 CFR are present."
State
Regulations: California Proposition 65
This product
does not contain components listed under the California Safe drinking
Water and toxic Enforcement Act of 1986 (Proposition 65)
Section 3.
Physical and Chemical Characteristics
| Boiling Point |
212 Degrees Fahrenheit |
| Specific Gravity |
1.05 |
| Vapor Pressure |
Same as water |
| Percent Volatile by Volume |
50% (water) |
| Vapor Density (air = 1) |
Same as water |
| Evaporation Rate (water = 1) |
Same as water |
| Solubility in water |
Insoluble |
| Appearance and Odor |
Black viscous liquid, mild characteristic
odor |
| Other |
pH (7.0 - 9.0) |
| VOC Content |
ZERO calculated,
(zero grams / liter) |
Section
4. Fire and Explosion Hazard Data
| Flash Point |
>212 Degrees Fahrenheit per
Method ASTM D-53 |
| Flammable limits in air, % by
volume |
Lower: Non-flammable
Upper: Non-flammable
|
| Extinguishing Media |
Water, dry chemical, CO2 |
| Auto-Ignition Temperature |
Not determined |
| Unusual fire and explosion
hazards |
None known, product is
non-flammable in aqueous form. Only dry product will burn. |
Section
5. Physical Hazards
| Stability |
Stable |
| Incompatible Materials |
None known |
| Hazardous Decomposition Products |
None known |
| Hazardous Polymerization |
Will not occur |
| Conditions to Avoid |
None known |
Section
6. Health hazards (signs and symptoms of exposure: see section 2)
| Threshold Limit Vale |
Not determined |
| Acute Overexposure |
EYE CONTACT: Avoid eye contact,
can cause irritation |
| INHALATION: No effects are
expected |
| SKIN CONTACT: Prolonged contact
can cause skin irritation |
| SWALLOWING: May cause stomach and
intestinal irritation |
| Chronic Overexposure |
None known |
| Conditions aggravated by exposure |
None known |
| Toxicity |
No data available |
| Listed as a potential carcinogen
by: |
|
|
NTP |
No |
|
I.A.R.C |
No |
|
OSHA |
No |
| Emergency First Aid Procedures |
|
|
Inhalation
|
In case of overexposure move
victim to fresh air. If breathing is difficult, give
oxygen and get medical attention. |
|
Eye Contact |
In case of eye contact flush eyes
with water for at least 15 minutes. Seek medical attention
is irritation persists. |
|
Skin Contact |
In case of contact wash skin with
soap and water |
|
Ingestion |
If swallowed do not induce
vomiting. Get medical attention immediately |
Section
7. Precautions for Safe Handling and Use.
| Precautions to be taken in
handling and storage |
Store at 40 - 110 Degrees
Fahrenheit. Provide adequate ventilation in the workplace |
| Steps to be taken if material is
released or spilled. |
Cover small spills using
absorbent, then sweep up and place in waste disposal container. |
| Waste Disposal Methods |
Dispose of in accordance with
Federal RCRA and applicable State and Local regulations. |
Section
8. Special Precautions and Spill / Leak Protection
| Respiratory Protection |
None required with adequate
ventilation |
| Ventilation |
General mechanical |
| Gloves |
Impervious. Neoprene rubber
recommended |
| Eye Protection |
Safety glasses or splash proof
goggles |
| Other |
Keep containers closed and
properly stored. Maintain an eyewash facility in work area |
| Transportation |
D.O.T. Emergency Guide No: Not
regulated |
The
information and Local laws and regulations contained herein is
based on data considered accurate. However, it is not to be taken as a
warranty or representation for which the manufacturer nor distributor
assumes legal responsibility. Any use of this information and data
must be determined by the end user to be in accordance with applicable
Federal, State
Date Prepared:
09/20/2004 Prepared
Y. Cunningham